SPECIFICATIONS
Fleming 65 Pilothouse Motoryacht
General Description
Main Engines: MAN R6-800 CRM 800 hp
Reduction Ratio: Nominal 2.5:1
Generator: 21.5Kw Onan eQD
Fuel: 1700 US gals in four tanks
Water: 400 US gals in four tanks
SPECIFICATIONS BY AREA OR GROUP
HULL
- Solid laminate commensurate for hull size, made in female mold.
- Vinylester resin used for outer laminations
- Full-length stringers and athwartships frames laminated over foam
- Simulated planking grooves
- Gelcoated finish above waterline
- Pettit, or equal, epoxy barrier coat below waterline.
- Integrally molded guard with s/s rub strip
- Keel extends below running gear
- Keel space filled and sealed across top
- FRP rudders with Aqualoy 22 Hi-strength stocks
- CE-approved S/S portlights
- S/S keel shoe 8 ft long
- ZF Faster I struts
- Shaft Tunnels (draft 5ft)
DECK AND SUPERSTRUCTURE CONSTRUCTION
- All parts made from molds.
- Corecell Cored construction with Cook gel coat
EXTERIOR
- S/S trim around roofs, on forward teak cap rail, and guard
- Italian made exterior locks
- S/S Aquasignal navigation and anchor lights
AFT DECK AREA
- Cockpit with teak decking.
- Flush lazarette hatches with hinges, gaskets, locks & gutters with drains
- FRP Swim step, with s/s brackets. Molded non skid surface. S/S rub rail
- Stainless steel telescopic swim ladder under swimstep. Can be deployed by swimmer
- Wide teak coaming around cockpit
- FRP skirt inboard of teak cap.
- Engine-room air intakes behind skirt and inside bulwarks
- S/S ladder to flybridge with teak treads
- Sliding doors to salon. Aluminum with FRP skin, glass windows & S/S strips
- Seadog style latches for doors
- Hot & cold shower fittings on inside of transom adjacent to door, with quick release shower head and flexi hose
- Salt water 316 S/S faucet
- Fresh Water 316 S/S faucet
- Shore inlets for 220v, 50A AC, Telephone, TV.
- Overhead low voltage lighting.
- LED rope lighting under coaming skirt
- Chocks at hull sides and transom (4)
- Six 14 heavy duty s/s cleats secured to plates inside bulwarks
- Deck scuppers piped out through transom at bootstripe
- Hatch with steps down into lazarette for access to engine room
- Integrally molded seats
- Integrally molded cockpit lockers
- 316 grade S/S 1 1/8 handrails across transom
- Courtesy LED "F logo lights at step up to salon
SIDE-DECKS
- Teak decking
- 316 grade S/S 1 1/8 handrails along house-side
- Teak rail cap on bulwarks
- Bulwark doors opening inboard with Seadog style latches and bolts
- Non-skid on top side of guard at boarding gates
- S/S overhead lights, two per side.
- Courtesy LED "F logo lights at steps up to Portuguese deck
- S/S handrails at side deck steps.
- Steps to Portuguese Bridge deck with teak treads
- House side windows fixed with tinted, tempered glass and FRP frames
- Galley & Pantry windows sliding with tinted, tempered glass and FRP frames
- Two sets of spring-line chocks per side
- Five 14" heavy duty s/s cleats per side, recessed into bulwarks
- Non-spill fuel fills in steps port and stbd. With custom S/S "F logo lids. Can fill all tanks from port or stbd.
PILOT-HOUSE DECK LEVEL
- Portuguese Bridge
- Teak rail cap
- Locker doors in aft face of Portuguese bridge
- 316 grade S/S 1 1/8 handrail around forward side of pilot house.
- 316 grade S/S 1 1/8 handrails at side of pilothouse Port & Stbd
- Sliding Aluminum p/house doors P & S with s/s weather seals
- Teak decking
- Hinged doors Port & Stbd through Portuguese bridge to foredeck with s/s gas spring retainers
- Individual Screen wash and heavy duty self-parking wipers on windshield
- Clear, tempered 9mm glass, in forward facing windshields
- Pilothouse windows are fixed and have FRP frames
FOREPEAK
- FRP Chain and rope lockers with removable s/s access plates and s/s chain pipes & rollers
- Watertight collision bulkhead
- Forepeak drains directly overboard.
- Bitter end fittings
- Hatch scuppers
- High gloss poly paint finish
- Overhead light
FWD DECK
- Cabin trunk with one large CE approved s/s skylight
- Deck lockers in cabin trunk
- S/S handrail on cabin trunk
- Teak rail cap on bulwarks increasing in width going fwd
- S/S stanchions to support teak handrail
- Teak hand rail
- S/S midrail
- Deck lockers fwd either side of anchor platform.
- FRP anchor platform with integrally molded non-skid and two sets of rollers
- Lofrans Titan "B 24v DC, 2000 watt, windlass with pendant control and remotes at both stations (P/H & F/B)
- Integrally molded beige non-skid on decks
- Beige Non-skid on top of cabin trunk.
- Four s/s chocks
- Eight 14 heavy duty s/s cleats
- 316 grade S/S pulpit 1 1/4" diameter tube. Welds ground and polished.
- Foredeck LED "F logo lights at steps through gates thru Portuguese bridge.
- Hatch to forepeak
- Two shore inlets for 220v AC, 50 amp & TV and phone.
- Salt water 316 S/S faucet inside foredeck lockers
- Fresh water 316 S/S faucet inside foredeck lockers
- Plug in for windlass control
- Deck drains plumbed to boot-stripe to prevent black streaks
FLYBRIDGE
- Lexan venturi with s/s rail
- Steering console with engine controls
- Helmseat for two persons at raised control station
- Electronics console
- Engine instrumentation
- Ritchie compass with light & dimmer
- BCS powered hydraulic steering with destroyer-type wheel
- Rudder angle indicator with light and dimmer
- AC source light
- Fire system repeater alarm
- L-Settee
- Table stbd side with fixed granite (or Corian) top
- Straight settee port side
- Flybridge cushions on settees and helmseat using EZ dri foam with Sunbrella upholstery and mesh backs for drainage
- Perfix snaps for attaching cushions
- Aquasignal navigation lights in accordance with appropriate Collision regulations
- Buell air horn with twin trumpets
- Two Mastervolt 24v to 12v DC-DC converters with 12v battery back-up system.
- Perfix snaps for attaching cushions
- FRP Radar arch with spreader lights
- S/S signal mast with bow and anchor lights and aft facing floodlight
- S/S railings with mid safety rail
- Starter engaged warning lights
- Main engine sea water flow alarms
BOAT DECK
- Integrally molded beige non-skid on deck
- 316 grade S/S handrails. 1 1/4" with 3/4" midrail.
- 1,500 lb capacity Steelhead davit with powered luffing, hoisting and rotation
- Hinged hatch to cockpit ladder
- GFCI 110v AC outlet
- Fresh Water 316 S/S faucet
- S/S saddles for tender (supplied loose)
- Aluminum plate inside deck for tender tie down
LAZARETTE
- Steering gear.
- BCS hydraulic power pack on anti-vibration mounts with FRP drip tray
- Deck and hatch scuppers
- Hull finished with gloss white polyurethane paint
- Overhead lights s/s
- 400 USG fresh water. 4 pcs polyethylene tanks with sight gages
- Variable frequency drives for 3-phase salon & pilothouse air-conditioning
- Air-conditioning compressors
- Aft shorepower inlet circuit breakers
- Fresh water pumps, inlet filter and pressure regulator
- Battery master switch panel
- Aft & main DC electrical panels
- Bow thruster Main Switch panel and fuse
- Submersible bilge pump
- Hi bilge alarm
- Starboard platforms and sole boards with s/s lifters
- Groco raw water strainers for aircon
ENGINE-ROOM
- Aquadrives with thrust plate, CV joints and soft engine mounts
- Bronze dripless shaft seals with Buck Algonquin "Seal Tight Packing
- Fire retardant FRP fuel tanks (4). With sight gages
- Equipment platforms
- Fuel transfer system with pump & flow meter
- Groco raw water strainers for engines gensets aircon and all seawater intakes
- Equipment platforms
- 21.5Kw Onan eQD genset with soundshield and combined muffler/water separator for exhaust
- Main engine exhaust system with water-lock muffler
- Engine room heat extraction blowers (2)
- Heavy duty sound insulation covered with perforated aluminum
- Engine access hatches locked down on gaskets
- Fire suppression system with auto engines/genset/blowers shutdown
- Heat detectors (3)
- Delta-T air intake baffles with auto-close in event of fire and guarded manual switch in cockpit
- Bilges painted with glossy white poly paint
- Sole board covered with Lonseal vinyl.
- Fresh Water fill hose for engines
- Submersible bilge pump
- Sump pump
- Hi-bilge alarm
- Control panels with VDO tacho & start/stop buttons for each engines
- Lube oil pumps (2) for engines, transmissions and generator
- AC and DC lighting
- 110v GFI electrical outlets
- Heavy duty Buell air-horn Compressor
- Anti-vibration soft mounts for genset
- Charles Isolation transformers (2)
- Mastervolt soft-starts (2)
- 900 A/H house battery bank consisting of 12 pcs Lifeline GPL 6CT AGM (6 volt)
- batteries
- 220 A/H port engine/genset starting battery bank
- 220 A/H stbd engine/genset starting battery bank
- FRP drip pans underneath main engines
- S/S mirror finished plates on inboard face of aft fuel tanks
- S/S mirror finished engine stringer caps
- Airtight FRP door with dog down latch with viewing port
- Starboard platforms and sole boards
- Lead foam sound insulation
INTERIOR
- Accommodation with three staterooms
- Hanging lockers lined with teak
- Insect screens for all opening windows, portlights and skylights
- Mobella interior door locks
- Cruisair reverse cycle air-conditioning with remote compressors and SMX-HT controls
- All cabins pre-wired for intercom/phone system
- LED mood rope lighting behind valances, stairs and settees
- Cantalupi brand lighting with 28v Xenon bulbs
- Teak joinery with satin varnish hand-rubbed finish
- Teak and holly sole throughout
- Light fixtures to have shiny s/s (chrome) finish
- Interior locker door handles to be brushed s/s finish
Standard three stateroom accommodation includes master cabin forward (en- suite) with two hanging lockers and vanity, port cabin with twin berths, hanging locker & vanity, stbd cabin with up & over berths, hanging locker and vanity, guest head to stbd. See drawing "FLEMING 65 Standard Accommodation"
Two choices of salon layout:-
1. L-Settee to port, Fleming Hi-Low table, aft wet bar with sink, refer/icemaker combo, stbd side entertainment centre with teak top & TV cabinet in aft corner. See drawing FLEMING 65 Salon Arrangement Option #1
2. Straight settee to port with cabinets at either end, aft wet bar with sink, refer/icemaker combo, stbd side dinette with dining table and light fixture above & TV cabinet in aft corner See drawing FLEMING 65 Salon Arrangement Option #2
SALON
- Fixed windows in house sides
- Opening windows in galley and pantry
- Sliding doors at aft end
- Medium grey tinted, tempered, glass.
- Wood window blinds
- Pre-wired for intercom/phone system
- Teak joinery with satin varnish hand-rubbed finish
- Granite (or Corian) counter tops
- Teak valance over windows with LED rope lighting
- Overhead light fixtures on dimmers
- Access hatch to allow for engine removal
- Ultrasuede headliner
- CO detector
- Air-conditioning
- FRP sandwich with Nidacore honeycomb composite sole
GALLEY
- Granite (or Corian) countertops
- Black composite double sink
- Insinkerator waste disposal
- Convection microwave oven
- Kenyon 4 burner flush cooktop with s/s potholders
- 20.5 cu ft side by side refrigerator/freezer
- Overhead light fixtures
- Grohe swivel faucet with removable spray head
- Trash compactor
- Drawers with guides and stops
- Cabinets
- Duplex 110v AC ground fault outlets
- Instahot
- Slide-out pot/appliance storage lockers (2) in forward bulkhead
- Slide-out pot/appliance storage lockers (2) aft cabinet
- Dishlocker at stbd side with opening top & front
- Slide out storage in pantry on stbd side
- Ultrasuede headliner
- Air-conditioning
PILOTHOUSE
- Chart table with double-guide drawers and stops
- Chart light on flexible arm
- Dismountable control console with space for owner supplied electronics
- Engine display screens on lower console
- Horn control
- Air reservoirs for Buell air horn (2)
- Rudder angle indicator with light & dimmer
- Back lit engine start & stop/Ignition buttons
- Engine power key-switches on advisory panel
- Electronic engine controls. Glendinning EEC 3 with back up gear and throttle with
- synchronizer and troll
- BCS powered hydraulic steering with Destroyer type steering wheel
- Ritchie Compass with light & dimmer
- Overhead electronics console
- Wiring routes to facilitate equipment installation
- Overhead light fittings with dimmer
- LED red and white dimmable bridge lights in upper console
- Stairs down to salon, up to flybridge
- Back lit electrical distribution panels for AC and DC
- Alarm and advisory panel
- Doors on AC, DC and advisory panels
- L-shaped settee on raised area
- Wood boat blinds on port window at settee
- Teak table with single s/s leg and swivel
- File drawer
- Self-parking, heavy-duty windscreen wipers with multi-speed/intermittent controls & individual fresh water wash on forward-facing windows
- Windshield glass, clear, tempered, 9 mm thick
- Ultrasuede headliner
- Deck Head
- Porcelain wash basin in granite counter top
- Locker and medicine cabinet
- Vented Wet locker with drain pan
- Tecma toilet
- Intake and discharge head vent fans
- Demister blower on forward facing windows
- Control for bow thruster
- Hinged soffit access to underside of flybridge console
- S/S handrail around dayhead
- Air-conditioning with ability to run on inverters whilst main engines are running
- ITIM Black water tank level indication and pump control panel
- Generator digital control panel
- Windlass up/down switch & control circuit breaker
- Fire system and high level bilge alarms panel
- Equipment running advisory panel
- Bilge and sump pump control on advisory panel
- Custom S/S fold down bookshelf fiddles
- Fleming Captains helm seat
- Pre-wired for intercom/phone system
- Dimmer for instrument lighting
- Starter engaged warning lights
- Main engine sea water flow alarms
ACCOMMODATION
PASSAGE
- Lower part of bulkhead teak. Upper part Ultrasuede. Teak chair-rail trim at join
- Access doors to staterooms
- Rope lights at stairs to salon and forward cabin
- Overhead low voltage Xenon lighting
- Manual bilge pump under steps
- Bosch washer and vented drier in cabinet behind sliding door
FORWARD STATEROOM
- Four s/s CE-approved Portlights
- CE approved skylight providing light, ventilation and emergency exit
- Oceanaire Insect and black-out screens for skylight
- Tapered queen-sized bed with hydraulic lift and manually slide
- Foam mattress
- Upholstered Headboard
- Teak lockers either side of bed
- LED Rope lighting under bed and steps
- Two hanging lockers. Teak faced with louvered doors. Automatic interior lights
- TV space on bulkhead
- Drawers with center guides and stops
- Beveled-edge mirrors
- Door stops and holders.
- Doors teak frame with flat teak panels and curved top
- Bulkheads with teak to waist height with Ultrasuede above
- Low voltage Xenon overhead lights on dimmers.
- Berth reading lights.
- CO detector
- Sump and condensate pump for air-conditioning
- Vanity at aft bulkhead
- Custom S/S fold down bookshelf fiddles
- Drapes
PORT HEAD (en Suite)
- CE-approved Portlight with removable insect screen
- FRP/PU coated shower stall with granite sole and auto sump pump
- Grohe shower mixer, pressure and temperature compensated
- S/S Toiletries rack in shower
- Marble or granite counter top with porcelain basin
- Grohe Faucets
- Beveled-edge mirrors
- Low voltage Xenon lighting
- 110v AC GFI outlet
- S/S Towel rails.
- Headhunter pressure-jet toilet. Bone color.
- Ventilator fan
- Drapes
STBD GUEST CABIN
- S/S CE-approved portlights with removable insect screens
- Upper & lower berths in "L configuration
- Hanging locker with louvered door & auto-light.
- Vanity with drawers
- 110v AC outlets
- Foam mattresses
- Upholstered Headboards
- Low voltage Xenon overhead lighting.
- Berth reading lights
- LED Rope lighting and drape tracks at portlight openings.
- Full height beveled-edge mirror
- Pocket entrance door
- CO detector
- Custom S/S fold down bookshelf fiddles
- Drapes
PORT STATEROOM
- S/S CE-approved portlights with removable insect screens
- Twin berths
- LED rope lights under berths
- Full height beveled-edge mirror
- Hanging locker with auto lighting and louvered door
- Valance over portlights
- Foam mattresses
- 110v AC outlets
- Upholstered Headboards
- Vanity and cabinets
- Low voltage Xenon overhead lighting
- Bookshelves
- Berth reading lights
- LED Rope lighting and drape tracks at portlight openings.
- CO detector
- Custom S/S fold down bookshelf fiddles
GUEST HEAD
- CE-approved Portlight with removable insect screen
- FRP/PU coated shower stall with granite sole, auto sump pump & seat and
- lockers
- S/S and glass custom shower doors
- Lockers
- Grohe shower mixer pressure and temperature compensated
- Marble or granite counter top with porcelain basin
- Grohe Faucets
- Beveled-edge mirrors
- Low voltage overhead Xenon lighting
- 110v AC GFI outlet
- S/S Towel rails.
- Headhunter pressure-jet toilet. Bone color.
- Ventilator fan
- Drapes
SYSTEMS
STEERING
- BCS powered electro/hydraulic
- FRP rudders with Aqualoy 22 stocks
- Destroyer wheel at flybridge and in pilothouse
- Back lit rudder angle indicators at pilothouse and flybridge stations
ENGINE CONTROLS
- Glendinning EEC 3 electronic at pilothouse and flybridge with back up system, synchronizer, and troll
MACHINERY
- MAN R6-800 CRM 800 hp Engines (2)
- Sidepower SP240TC 15.5 HP (11.4 Kw) bow thruster with Sidepower Main
- Switch and controls at each station
- ZF-Faster 4-blade Nickel Aluminum bronze propellers
- Shafts Aqualoy 22 Hi-Strength 2 Ύ
- Cutless-type shaft bearings
- ZF-Faster recessed I-struts in shaft pockets
- Aquadrive anti-vibration system, couplings and engine mounts
- Bronze drip-less shaft seals with Buck Algonquin "Seal Tight Packing
- Underwater exhaust and internal water-lock muffler system
- Bennett S/S SST trim tabs with indicators and controls at pilothouse and flybridge stations
FUEL SYSTEM
- Fuel filters. Racor 75/1000MAX Duplex with vacuum gauges for main engines.
- MAN Primary fuel filters with water-in-fuel sensors for main engines
- Racor 500MA fuel filter for generator
- 4 FRP fuel tanks made of vinylester and fire retardant resins
- Total fuel capacity 1,700 USG
- Fuel tank sumps and drains with shut-off valves on all tanks
- Fuel management panel for engine/genset supply return selection
- High capacity 24v DC Fuel Transfer pump with suction & delivery manifolds
- Digital fuel flow meter for transfer system
- Fuel tank float switches and Hi-level alarm
- Sight glasses on all fuel tanks with self-closing safety valves
- Electric fuel priming pumps for main engines
- Computank Fuel & Water tank level indication system, using pressure type senders
PLUMBING
SANITARY
- Headhunter Neo-classic at each of 2 heads, Bone color.
- Toilets flush to FRP holding tank with level indicator or directly overboard
- Toilet flushing for both Seawater and Freshwater.
- Anti-odor filters on holding tank vents Port & Starboard
- 330 gal Black water tank
- Headhunter 110v AC black water discharge pump
- Back up 24v DC Sealand macerator pump
- Tecma toilet in pilothouse day-head
- ITIM Tank monitoring / pump control system
- Plastic lined pressure accumulator tank
- Black water tank suction deck fittings port and stbd side
- Black water tank seawater flushing system, with self closing safety valve
FW SYSTEM
- 400 USG total in four polyethylene tanks, with drain and isolation valves.
- Sight glasses on water tanks
- Mach 5 110v AC Headhunter fresh water pump
- Back up X-Caliber 24v DC Headhunter Fresh water pump
- 40 USG Torrid water heater with two 220v AC heating elements and two heat
- exchanger coils, drain & pressure release valves.
- Heat exchanger system and circulation pump for heating domestic water from
- port main engine
- Hot water Re-circulation solenoid valve and timer with switches in both heads
- Fresh Water 316 S/S faucet on foredeck
- Fresh Water 316 S/S faucet on flybridge
- Fresh Water 316 S/S faucet in cockpit
- Grohe interior faucets
- Whale plumbing system
- Whale gulper shower sump pumps
- Fresh water coil hose in engine room
SW SYSTEM
- X-Caliber 24v DC Headhunter seawater pump and strainer
- Salt water 316 S/S faucet on foredeck
- Salt water 316 S/S faucet in cockpit
- Sea water flush line connected to black water tank, with self closing safety valve
- Whale brand plumbing
- Groco intake strainers for main engines, generator and sea water system
BILGE SYSTEM
- 3 pcs Rule electric bilge pumps with auto/man control
- Manual bilge pump for forward bilge compartment
- Forward bilge sump pump Whale Gulper
- Engine room bilge sump pump Whale Gulper
- Hi-level bilge alarm switches in lazarette, engine room, and forward bilge
ELECTRICAL
ELECTRICAL - AC
- 21.5Kw Onan eQD generator, 220v single phase, in sound shield mounted on anti-vibration soft mounts
- Load distribution panel. Split panel system. Sub panels as required
- Digital meters (volts, amps, watts and frequency) and circuit breakers as required
- Four 220v, 50 amp shore inlets fore and aft connected so as two can be used simultaneously
- AC outlets throughout boat. GFI type in heads, galley, engine room and exterior
- Imtra light switches and dimmers.
- Two 3,500 watt stacked pure sine wave Outback inverters
- Integral inverter bypass system
- Inverter remote control panel in pilothouse.
- Charles Isolation transformers (2)
- Mastervolt soft starts (2)
- AC Contactor Box
- Tinned copper wire used throughout
ELECTRICAL - DC
- Main ships system 24v DC.
- Three isolated battery banks
- 12v DC via two 24v-12v DC-DC converters & back-up battery system located on flybridge
- Battery disconnect and selector switches accessible from outside engine room
- Mastervolt 15 amp battery charger for engine/genset starting batteries (24v)
- DC load distribution center with breakers.
- Link 10 digital battery monitor
- Alarm panel for engine functions, bilge, fire, sea-water flow etc
- Advisory indicators for key pumps and engine room lights
- 140 amp Balmar auxiliary alternators on each engine with Balmar multi-stage external regulator
- 900 A/H house battery bank consisting of 12 pcs Lifeline GPL 6CT AGM (6 volt) batteries
- Tinned copper wire used throughout
ELECTRICAL - BONDING
- Copper strap or cable connecting all thru-hulls, underwater fittings, pulpit and flybridge rails (equipotential bonding system)
- Zincs on transom (2)
- Zincs on trim tabs (2)
- Copper strapping system in engine room, flybridge and pilothouse for SSB radio counterpoise
MISCELLANEOUS OUTFIT
- Cruisaire reverse cycle air-conditioning throughout using REU model quiet
- blowers and SMX HT controls
- Sump and condensate pump for air-conditioning in forward cabin
- Ball-type seacocks on all through hulls at or below waterline
- Sika-Flex deck Caulking
- 5/8 thick teak deck
- Lead foam insulation between accommodation bulkheads
- Pre wiring with coax, CAT 5 and speaker cables throughout as follows:-
- CAT 5 - 2 x from salon stereo cabinet to behind FB inboard panel, PH console & each cabin
- Speaker wire - 2 x from salon stereo cabinet to FB radar arch port and stbd, PH console, each cabin, laz or aft deck overhead
- COAX - 1 x from salon stereo cabinet to behind FB inboard panel, PH console, and each cabin
- COAX - 4 x from salon stereo cabinet to FB stbd settee near davit base
AFTERWORD
The question most manufacturers ask themselves when considering a new feature is whether it is necessary to include it in order to sell the boat. In the case of the Fleming, we ask only whether its inclusion will make the boat safer, better or more convenient. That is why we have introduced literally hundreds or refinements since we started construction in 1985 and why we continue the process today.
For that reason Fleming Yachts reserves the right to make changes to specifications and equipment without notice.
Copyright 2008 Fleming Yachts